The relay and fuse box is also called the mounting block or black box. If a vehicle malfunction is detected related to electrical equipment, the fuses and relays are first checked. If a fuse is blown, you must first determine the cause of its blown before replacing it.
Where are the fuses for Lada Kalina 2?
The fuse box is located near the driver's left foot. Pull the lower left corner of the cover (#1) to release the left locking point, then the middle (#2) and the two right locking points (#3 and 6). Then release the upper locking points (No. 4 and 5) and remove the cover.
Installing the fuse box cover is carried out in the following order: first snap the right fastening elements, then the lower ones, and then the upper ones. Make sure that the fastening elements of the cover are aligned exactly with the metal fasteners.
On the plastic cover of the mounting block there are symbols that indicate what each fuse (F) and relay (K) is responsible for, as well as their numbering.
What to do if replacing the fuse does not help
There are additional faults due to which the device on Kalina may break. These include.
- Bad contacts. Over time or from heavy use, the connection inside the device may become compromised. Incorrect installation of devices leads to loose sockets and poor contact. The fuse trips. This can be treated by bending the metal tendrils on the cartridge, as well as by resoldering the contacts.
- With age, oxides or rust appear on Kalina's cigarette lighter, which has a bad effect on its operation. The situation can be corrected by treating the contact areas with a needle file. It is necessary to clean them and remove all traces of corrosion. Another malfunction is a burnt-out nichrome spiral. It is recommended to replace the device here.
The price of a new cigarette lighter for Kalina is 300 – 750 rubles. When choosing, you need to buy original parts. They must be carefully packaged, and quality certificates and certificates of conformity must be located inside. When buying cheap Chinese analogues, be prepared for the fact that the fuses may burn out, and the device itself may not work for long and incorrectly.
Fuse diagram Lada Kalina 2
The table shows a set of fuses for the maximum configuration of the “luxury” version (depending on the set of options, individual fuses from this set may not be used in the “Normal” configuration).
| Number and current* | “Standard” package | Equipment “Norma” and “Lux” |
| F1 (15A) | Ignition Coils, Injectors, Engine Control System Controller | |
| F2 (10/30A) | Daytime Running Lights | Power supply for the body electronics central unit, Driver's door module. |
| F3 (10/15A) | Alarm | Automatic transmission controller power supply, Automatic transmission control drive. |
| F4 (15A) | Airbag system controller | |
| F5 (7.5A) | Terminal 15 devices | |
| F6 (7.5A) | Reversing light | Reverse Light, Automatic Transmission Controller |
| F7 (7.5A) | Canister purge valve, mass air flow sensor/pressure sensor, DC | Canister purge valve, mass air flow sensor/pressure sensor, phase sensor, DC. |
| F8 (7.5A/-) | Direction indicators | Reserve |
| F9 (5A) | Side lights on the starboard side. | |
| F10 (5A) | Parking lights on the left side, Illumination of instruments and keys, License plate lights, Luggage and glove box lighting. | |
| F11 (5A) | Rear PTFs. | |
| F12 (10A) | Low beam and power supply for starboard electric corrector. | |
| F13 (10A) | Low beam and power supply for the left side electric corrector. | |
| F14 | Reserve | |
| F15 (10A) | Rear window washer, Rear window wiper | |
| F16 (-/5A) | Reserve | Driver door module |
| F17 | Reserve | Reserve |
| F18 | Reserve | Reserve |
| F19 (20A/-) | Door lock | Reserve |
| F20 | Reserve | |
| F21 (10A) | High beam, right headlight | |
| F22 (10A) | High beam, left headlight | |
| F23 (-/10A) | Reserve | Right fog lamp |
| F24 (-/10A) | Reserve | Left fog lamp |
| F25 (15A) | Heated front seats | |
| F26 (5A) | Anti-lock brake control unit | |
| F27 (15A) | Cigarette lighter | |
| F28 (15A) | Fuel pump | |
| F29 (20A) | Windshield washer | Windshield washer, Central body electronics unit |
| F30 | Reserve | |
| F31 (-/7.2A) | Reserve | Air conditioning compressor clutch, Automatic climate control system controller |
| F32 (7.5A) | Brake lights, Interior lighting | |
| F33 (25A) | Anti-lock brake control unit | |
| F34 (5A) | Instrument cluster, Diagnostic connector | |
| F35 (-/10A) | Reserve | Central body electronics unit |
| F36 (10A) | Sound signal | |
| F37 (10A) | Radio/Multimedia system | |
| F38 | Reserve | |
| F39 | Reserve | |
| F40 | Reserve | |
| F41 | Reserve | |
| F42 (30A/-) | Electric windows | Reserve |
| F43 (-/50A) | Reserve | AMT controller |
| F44 (30A) | Electric heater fan | Electric heater fan, Automatic climate control system controller |
| F45 (25A) | Heated rear window | |
| F46 | Reserve | |
* — the first value for the “standard” configuration, the second for “norm” and “luxury”.
Fuses located in the mounting block of the vehicle interior with the ERA-GLONASS function (in a variant):
| № | Current strength | Protected Circuits |
| F1 | 15A | Minimum speed radiator fan relay K18 (version with air conditioning or climate control) |
| Maximum speed radiator fan relay K4 | ||
| Air conditioning compressor clutch relay K10 (version with air conditioning or climate control) | ||
| Engine Control System Controller | ||
| Cylinder injectors | ||
| Ignition coils (for 16-valve internal combustion engines) | ||
| F2 | 7.5A | Intake pipe damper valve (for 16-valve internal combustion engine 21127) |
| Canister purge valve | ||
| Oxygen sensors | ||
| Phase sensor (for 16-valve internal combustion engine) | ||
| Mass air flow sensor (for 8-valve internal combustion engine or 16-valve internal combustion engine 21126) | ||
| AMT selector (version with AMT controller) | ||
| Tire pressure monitoring system control unit (terminal 30) (for EURO-6 vehicles) | ||
| F3 | 5A | Anti-Lock Brake Controller / Stability Control Controller |
| F4 | 15A | Airbag system control controller |
| F5 | 7.5A | Starter Relay K2/Automatic Transmission Controller |
| Unloading relay of ignition switch K1 | ||
| Rear window heating relay K6 | ||
| Seat heating relay K13 (optional) | ||
| Heated windshield relay K14 (optional) | ||
| Fuel pump relay K12 | ||
| Engine Control System Controller | ||
| Audio system | ||
| Electric Power Steering Controller | ||
| Wiper switch | ||
| Central body electronics unit (optional) | ||
| Terminal block "ERA-GLONASS" | ||
| Clutch pedal switch (for manual transmission) | ||
| Brake pedal switch | ||
| Instrument cluster | ||
| Door lock system control unit (optional) | ||
| Driver's door lock switch | ||
| Air conditioner switch (optional) | ||
| Automatic transmission speed sensor (optional) | ||
| Automatic transmission mode switch (optional) | ||
| AMT controller (optional) | ||
| Tire pressure monitoring system control unit (for EURO-6 vehicles) | ||
| F6 | 7.5A | Reversing light |
| Direction indicators | ||
| Parking system control unit (optional) | ||
| F7 | 10A | Starboard high beam |
| F8 | 10A | Left side high beam |
| F9 | 5A | Side lights on the starboard side |
| F10 | 5A | Left side marker lights |
| License plate lights | ||
| Trunk light | ||
| Illumination of instruments and keys | ||
| F11 | 5A | Rear fog lights |
| F12 | 10A | Starboard low beam |
| F13 | 10A | Left side low beam |
| Headlight electric adjustment control (optional) | ||
| F14 | 20A | Central body electronics unit: |
| (Windshield wiper) (optional) | ||
| Windshield washer | ||
| Windshield wiper | ||
| Steering column wiper switch | ||
| F15 | 10A | Rear window wiper |
| Rear window washer | ||
| F16 | RESERVE | |
| F17 | RESERVE | |
| F18 | RESERVE | |
| F19 | RESERVE | |
| F20 | RESERVE | |
| F21 | 15A | Fuel pump motor |
| F22 | 7.5A | Brake light switch |
| Brake lights | ||
| Additional brake signal | ||
| Anti-Lock Brake Controller/ Stability Control Controller | ||
| AMT controller (optional) | ||
| F23 | 5A | Instrument cluster |
| Diagnostic connector | ||
| F24 | 10A | Horn relay K8 |
| Sound signal | ||
| F25 | 15A | Socket for connecting additional consumers in the cabin |
| F26 | 5A | Terminal block "ERA-GLONASS" |
| F27 | 10A | Starboard fog lamp (optional) |
| F28 | 10A | Left side fog lamp (optional) |
| F29 | 15A | Heated front seats (optional) |
| F30 | 10A | Audio system |
| F31 | 10A | Central body electronics unit: (Direction indicators; Power supply for body electronics unit) (optional) |
| F32 | 30A | Central body electronics unit: (Power windows; Door and trunk locks; Rain sensor; Glove box light; Trunk light; Interior light unit; Daytime running lights) (in a variant) |
| F33 | 5A | Driver door module |
| F34 | 7.5A | Air conditioning compressor clutch (version with air conditioning or climate control) |
| Controller for automatic climate control system (optional) | ||
| F35 | 15A | Automatic transmission controller (optional) |
| Automatic transmission control drive (optional) | ||
| F36 | 15A | Alarm |
| F37 | 15A | Trunk lock actuator switch |
| Door lock control unit | ||
| 5A | Trunk lock actuator switch | |
| F38 | 10A | Daytime Running Lights |
| F39 | 15A | Cartridge for connecting additional consumers in the trunk |
| F40 | 10A | To the trailer lighting connector |
| F41 | 50A | Heated windshield (optional) |
| F42 | 30A | Heated exterior mirrors (optional) |
| Heated rear window | ||
| F43 | 50A | AMT controller (optional) |
| F44 | 30A | Electric heater fan |
| Controller for automatic climate control system (optional) | ||
| F45 | 30A | Power windows for front doors |
| F46 | RESERVE |
Video instruction
Sometimes a complete replacement of the device is required. To do this, you need spare parts and a standard screwdriver. The order of work is as follows.
- Open the hood, find the battery and remove the negative terminal from it.
- We unscrew the three mounting bolts around the parking brake handle, which is located on top of the central tunnel. We dismantle the hand brake limit switch.
- We unscrew the rear fastening screw, as well as additional screws on the sides.
- Remove the cover from the gear lever, and then lift the tunnel cover.
- We disconnect the power plug coming to the electrical wiring circuit.
- We press the special latches that hold the device itself. Once it pops out, you can replace it.
- Next, we install the new part on the Lada Kalina and carry out the reassembly process.
The video below will help you understand where it is located and how to replace the cigarette lighter fuse of the Lada Kalina model.
Relay diagram Lada Kalina 2
A set of relays is indicated for the maximum configuration of the “luxury” version (depending on the set of options, individual relays from this set may not be used in the “Normal” configuration).
| Number | Current* | “Standard” package | Equipment “Norma” and “Lux” |
| K1 | 50A | Unloading relay | |
| K2 | 30A | Additional starter relay | |
| K3 | 30/40A | Wiper relay | Radiator cooling fan relay |
| K4 | 30A | Radiator cooling fan relay | |
| K5 | 30A | Turn signal relay | A/C compressor clutch relay |
| K6 | 30A | Power window relay | Heated rear window relay |
| K7 | 20A | High beam relay | |
| K8 | 20A | Horn relay | |
| K9 | 20A | Low beam relay | |
| K10 | -/20A | Reserve | Reverse light relay (in versions with automatic transmission) |
| K11 | 20A | ECM main relay | |
| K12 | 20A | Fuel pump relay | |
| K13 | 20A | Seat heating relay | |
| K14 | 30/70A | Alarm relay | Heated windshield relay |
| K15 | 30A/- | Heated rear window relay | — |
| K16 | 30A/- | Additional alarm relay | — |
* — the first value for the “standard” configuration, the second for “norm” and “luxury”.
Relays located in the mounting block of the car interior with the ERA-GLONASS function (in a variant):
| # | Denomination | Relay purpose |
| K1 | 50A | Ignition switch unloading relay |
| K2 | 30A | Additional starter relay |
| K3 | 30A | Windshield wiper relay (optional) / Auto start relay |
| K4 | 30A | Maximum speed radiator fan relay (optional) |
| K5 | 30A | Turn and hazard warning relay (optional) |
| K6 | 30A | Heated rear window relay |
| K7 | 20A | High beam relay |
| K8 | 20A | Horn relay |
| K9 | 20A | Low beam relay |
| K10 | 20A | Air conditioning compressor clutch relay (version with air conditioning or climate control) |
| K11 | 20A | ECM main relay |
| K12 | 20A | Fuel pump relay |
| K13 | 20A | Seat heating relay (optional) |
| K14 | 70A | Heated windshield relay (optional) |
| K15 | 20A | Alarm relay |
| K16 | 30A | Hazard power relay/reverse light relay (optional) |
| K17 | 30A | Power window power relay/radiator fan relay in auto start mode |
| K18 | 30A | Minimum speed radiator fan relay (optional) |
Mounting block in the engine compartment
A set of fuses is indicated for the “luxury” version. In other versions, individual fuses from this set may not be used.
| Fuse no. | Current strength | Protected Circuits |
| FF1 | 50A | Heated windshield |
| FF2 | 60A | Generator |
| FF3 | 60A | Generator |
| FF4 | 40A (without air conditioning - 30A) | Electric radiator cooling fan |
| FF5 | 50A | Electromechanical power steering |
| FF6 | 40A | Anti-lock brake control unit |
Fuses located in the fuse box of the engine compartment of a car with the ERA-GLONASS function (in a variant):
| # | Denomination | Protected circuit |
| FF1 | 60A | Generator |
| FF2 | 60A | Generator |
| FF3 | 30A | Electric radiator cooling fan |
| 40A | Electric radiator cooling fan (version with air conditioning or climate control) | |
| FF4 | 40A | Anti-Lock Brake Controller / Stability Control Controller |
| FF5 | 25A | Anti-Lock Brake Controller / Stability Control Controller |
| FF6 | 50A | Electric Power Steering Controller |
Attention!
The relay and fuse diagram may differ depending on the configuration and production date of the vehicle. Current diagrams of the mounting block are presented in the operating manual for the date of manufacture of the car (download from the official website for a hatchback or station wagon).
Let us remind you that you will find other useful instructions in the section Repair and operation of Lada Kalina 2.
Keywords: mounting block Lada Kalina | Lada Kalina torpedo
1 0 0 0 0 0
Share on social networks:
conclusions
If a relay fails or a fuse melts in the unit on a Lada Kalina, the electrical circuits that are responsible for the operation of the unit may fail. Thus, before repairing the mechanical part, it is worth checking the condition of the fuse. The combustion of these parts occurs due to a short circuit in the Kalina on-board network.
Modern car enthusiasts rarely use this socket for its intended purpose. Additional devices such as charging for a phone or other devices are connected to the cigarette lighter socket. The most common:
- electric compressor;
- GPS navigator for route calculation;
- DVR;
- charger for mobile phone, laptop or tablet.
Over time, this device may break down: fuses may burn out or wires may melt. This is fraught with a lot of inconvenience even for a non-smoking driver. How to replace the cigarette lighter fuse of a Lada Kalina car, where the mounting block is located and other nuances of the work are described below.
